water tube boiler handbook

Industrial boilers

Product thermal capacity: 4-35 t/h

Working pressure: 1.0-2.5 MPA

Outlet temperature: 184-350 ℃

Available fuel: natural gas, coke oven gas, bio-gas,liquid propane gas, diesel, heavy oil, light oil, crude oil

Available industries: Petroleum, chemical, chemical fiber, pharmaceutical, textile printing and dyeing, building materials, wood processing, vegetable oil processing and other industries

  • Product introduction
  • Technical advantages
Introduction

water tube boiler handbook have a three-pass round coil structure. A conical coil is used for the effective protection of the furnace wall at the boiler end. This product is equipped with an advanced combustion device and is fully automated in operation. After the burner ignites the fuel, flame fills the round coil tubes and transfers heat by radiation through the tube wall (first pass). The high temperature flue gas gathers at the back door and then turns to the convection tubes section (second pass), where heat transfer takes place by convection. The flue gas gradually cools down here and flows to the front door, where it is reversed and goes into the third pass. After that, it enters into the chimney through the economizer and is released into the atmosphere.


water tube boiler handbook.This type of heater is delivered as a whole, and is installed on site, it only needs to connect thermal gas(oil) piping and electricity to start operation. The heater has four heating areas: furnace radiation heating area, the first convection tube bundle heating area, the second convection tube bundle heating area and economizer (waste heat boiler).

Digitized manufacture
  • The laying-off of steel tube adopts CNC 3D laser cutting machine.
  • The manufacture of round coil tube adopts CNC coil tube automatic production line. Once-forming and no need for plastic .
Full argon arc welding
  • The tube butt adopts argon arc welding technique and the seams will be done x ray real-time imaging, preventing unqualified seams from entering coil production line .
Easy operation
  • Heater is wholly assembled before delivery, it is easy for installation, debugging and operating.
  • Fully automatic operating, burning, liquid level of high level tank, outlet temperature and flow rate are adjusted automatically and self-protected.
  • The inlet and outlet with end flanges and flanged cover structure facilitate the installation and layout of tubeline in boiler house.
Less fuel consumption
  • Internal side adopts good insulation material, outside uses stainless steel plate, which can mostly reduce heat lost and make working environment better.
  • Multilayers closely spaced tube bundle and steel rod is used to seal and fix, completely eradicating short circuit of flue gas.
  • Before delivery, the residue moisture is removed completely, so the system draining period is reduced to 2 days from 12 days.
Safely operation
  • The inner coil tube has bigger flow rate, so it is more stable under high temperature operation.
  • Conical coil effectively protects the furnace wall at the end of heater and burner on the top.
water tube boiler handbook water tube boiler handbook water tube boiler handbook

Service Handbooks - Water Heate

2019-9-13 · Legend® Service Handbook Deliming copper tube heat exchanger manual: Deliming Procedure VF™ II Hydronic Heating Boilers VW/VB-1500 – VW/VB-2000 Series 100, 101: VF™ Service Handbook XB/XWH - 1000 thru 3400 - 100/101: XB/XWH - Service Handbook - 10638001 XP Plus 100/101 - Circulating Water Heaters: XP Plus - Service Handbook - 100307056

lexie@zozen.com > Get A Quote >

fire tube boiler handbook - unic.co.

Comparison Between Fire Tube and Water Tube Boiler. Comparison between Fire Tube and Water Tube Boiler can be done in 14 aspects. Those aspects are operating pressure, passage of material type in tubes, rate of steam generation, handling of load fluctuation, floor area requirement, efficiency, operator skills, design, maintenance cost are listed below in the tabular form.

lexie@zozen.com > Get A Quote >

CHAPTER 39 BOILER WATER TREATMENT - ssu.ac.

2015-5-26 · CHAPTER 39 BOILER WATER TREATMENT Of the many uses for energy in the United States today—in industry, in trans- causing poor heat transfer and a potential for boiler tube failure. In low-pressure. FIG. 39.4 Deposits on the water-side of a boiler tube insulate the metal from the cooling effect of water flow. The metal on the

lexie@zozen.com > Get A Quote >

Boilers

2004-3-19 · Fire-Tube Boiler (~1800) The fire tube boiler, the oldest design, is made so the products of combustion pass through tubes surrounded by water in a shell. The furnace/flame volume can either be inside or external to the shell that contains the water. The upper steam capacity of fire tube boilers is about 20,000 Ibm/hr, and the peak pressure

lexie@zozen.com > Get A Quote >

Boiler room Guide - cleaverbrooks.c

2018-8-5 · The watertube boiler design (see Figures 1-3 & 1-4) uses tubes to direct the boiler water through the hot gases from the combustion process, allowing the hot gases to transfer its heat through the tube wall into the water. The boiler water flows by convection from the lower drum to the upper drum. FiFTh pASS FOurTh pASS ThirD pASS SECOND pASS

lexie@zozen.com > Get A Quote >

(PDF) BOILER TUBE FAILURE ANALYSIS - ResearchGa

PDF On Jan 1, 2015, Eaugen Furamera and others published BOILER TUBE FAILURE ANALYSIS We use cookies to make interactions with our website easy and meaningful, to better understand the use of

lexie@zozen.com > Get A Quote >

Operation and Types of Water Tube Boiler -

2019-9-17 · A water tube boiler is such kind of boiler where the water is heated inside tubes and the hot gasses surround them. This is the basic definition of water tube boiler. Actually this boiler is just opposite of fire tube boiler where hot gasses are passed through tubes which are…

lexie@zozen.com > Get A Quote >

Service Handbook COMMERCIAL BOILERS/WATER HEATE

2019-1-28 · If the boiler/water heater is installed in beauty shops, barber shops or laundries with dry cleaning equipment, it is imperative the boiler/ water heater be installed in a Direct Vent configuration so that air for combustion is derived directly from the outdoor atmosphere through a sealed intake air pipe.

lexie@zozen.com > Get A Quote >

Operation and Types of Water Tube Boiler -

2019-9-17 · A water tube boiler is such kind of boiler where the water is heated inside tubes and the hot gasses surround them. This is the basic definition of water tube boiler. Actually this boiler is just opposite of fire tube boiler where hot gasses are passed through tubes which are…

lexie@zozen.com > Get A Quote >

DRAFT BOILER/FEEDWATER GUIDELIN

2017-3-20 · pitting can result with possible rupture of boiler condensate piping or boiler tubes. 3.3.4 Rusty water in the boiler gage glass is a sure sign of acid corrosion in the boiler feedwater/condesate system or in the boiler itself. 3.3.5 Make-up water is the major source of carbon dioxide. The first priority is to minimize the amount of make-up water.

lexie@zozen.com > Get A Quote >

Glossary of boiler terms - Wikiped

2019-9-7 · large external pipes in many water-tube boilers, carrying unheated cold water from the steam drum down to the water drum as part of the circulation path. Drowned tube Either a fire-tube or water-tube that is entirely below the water-level of the operating boiler.

lexie@zozen.com > Get A Quote >